ClO2氧化法预处理联苯胺类染料中间体废水

采用ClO₂氧化法预处理联苯胺类染料中间体生产废水，探讨了影响COD和联苯胺去除率的主要因素，并采用GC/MS技术对ClO₂氧化前后废水中的有机组分进行了分析。实验确定了较佳的工艺参数：ClO₂加入量为45~55 mg/L，ClO₂与联苯胺的化学计量比控制在（3.0~3.5）∶1，反应时间为 30~35 min。在此条件下，ClO₂氧化后出水中联苯胺去除率达到80%以上，联苯胺类污染物含量得到有效降低，废水BOD₅/COD由原水的0.18提高到0.40。该方法能提高废水的可生化性，是一种较好的生化预处理技术。     

A method for the determination of rhodamine b and brilliant sulfaflavine on cotton string collectors and in a spray tank solution mixture

Abstract

A fluorescent method for the determination of rhodamine B (RhB) and brilliant sulfaflavine (BSF) dual tracers on cotton string collectors and in spray tank solutions was developed for the evaluation of the effects of adjuvants on the atmospheric drift of agricultural sprays. Both tracers on collectors were extracted with deionized water simultaneously and measured directly with a Fluorescent Specrometer by switching the maximum excitation and emission wavelengths. The linear ranges of the RhB and BSF standard curves were 0–50 and 0–10 ppb respectively. Recoveries of tracers on cotton strings ranged from 92.9% ± 1.1% to 95.1% ± 1.0% for RhB and 91.9% ± 2.8% to 103% ± 0.6% for BSF when spiked levels ranged from 0.25 to 2.5 μg per collector. The detection limit of the instrument was approximately 0.1 ppb for both tracers. The detection limits of the analytical method were approximately 0.1 ppb for RhB and 0.3 ppb for BSF when the background levels of cotton strings were subtracted. The presence of one tracer in the solution did not significantly interfere with the detection of the other tracer in the same solution. The presence of adjuvants added to the spray tank solutions did not interfere with the detection of both tracers when the adjuvants were applied at the manufacturer's maximum recommendation rates.     

累托石对水中染料碱性桃红的吸附

采用累托石作为水中碱性桃红的吸附剂.考察了振荡时间、pH值、累托石用量、碱性桃红初始浓度等因素对吸附效果的影响.测定了吸附等温线,对吸附动力学规律进行了数学模拟.结果表明,振荡时间、累托石用量、碱性桃红初始浓度等因素对吸附效果有重要影响.对于初始质量浓度为50 mg/L的碱性桃红水溶液,最适宜吸附条件为:振荡时间30 min,累托石用量200 mg/100 mL,pH值为6.累托石对水中碱性桃红的吸附等温线呈"S"型,等温吸附规律可用Freundlich模式较好地描述,吸附动力学规律可用Bangham公式模拟.     

雾化介质阻挡放电联合电晕放电对染料溶液脱色研究

实验将介质阻挡放电与电晕放电组合在一个反应器内,以靛蓝二磺酸钠溶液为实验废水,将高压电极上通入50Hz交流高压电,在常压空气中形成介质阻挡放电-电晕放电系统,放电产生的低温等离子体及其活性基团作用于染料分子。考察了电源电压、电极间距、处理时间对染料溶液脱色率和能量效率水平的影响,确定反应器工作状态为介质阻挡放电系统电极间距30mm、电晕放电系统电极间距25mm、电源电压20kV。     

Loofa egyptiaca as a novel adsorbent for removal of direct blue dye from aqueous solution

In this paper, Loofa egyptiaca (LE), an agricultural plant cultivated in Egypt, was used to prepare low-cost activated carbon (LE_C1 and LE_C2) adsorbents. The adsorbents (LE, LE_C1 and LE_C2) were evaluated for their ability to remove direct blue 106 dye from aqueous solutions. Batch mode experiments were conducted using various parameters such as pH, contact time, dye concentration and adsorbent concentration. The surface chemistry of LE, LE_C1 and LE_C2 was analyzed by scanning electron microscopy (SEM). The experimental data were examined using Langmuir, Freundlich, Temkin and Harkins–Jura isotherms. The results showed that the adsorption of direct blue 106 was maximal at the lowest value of pH (pH = 2). Removal efficiency was increased with an increase in dye concentration and a decrease in amount of adsorbent. Maximum adsorption capacity was found to be 57.14, 63.3 and 73.53 mg/g for LE, LE_C1 and LE_C2 respectively. Kinetics were also investigated using pseudo-first-order, pseudo-second-order and intra-particle diffusion models. The experimental data fitted very well with the pseudo-first-order and pseudo-second-order kinetic models. The results indicate that LE, LE_C1 and LE_C2 could be employed as adsorbents for the removal of direct blue dye from aqueous solutions.     

蒽醌染料中间体溴氨酸降解酶的特性

从污染地分离筛选出的菌株BX26对蒽醌染料中间体溴氨酸有显著的降解脱色作用，降解过程受降解酶的控制，试验结果表明，降解酶为溴氨酸诱导的胞外酶，该酶在温度高于50℃处理后失活，盐度对该酶失活有影响，盐度高于1%会显著降低该酶活力，酶对溴氨酸的催化脱色要有氧参加，氮气气氛中酶活受抑制。     

电-生物耦合技术对偶氮染料的去除研究

酸性大红GR是一种较难生物降解的偶氮染料，采用一种电场和生物耦合的新型技术处理酸性大红GR模拟废水，并与单纯电化学法和好氧生物法进行试验对照。结果表明：反应6 h后，电化学法、好氧生物法、电-生物耦合技术对酸性大红GR的去除率分别达到15.7%、25.8%和71.2%，电-生物耦合技术能明显提高酸性大红GR的去除效果，起到强化生物处理的作用。在15 mA微电流条件下电-生物技术能克服50 mg/L酸性大红GR对好氧生物处理的抑制作用，为高浓度难降解染料废水的生物强化处理提供了可能。     

颗粒活性炭吸附染料的类分形动力学特征的研究

建立了复杂分子吸附反应时指数h与分形子谱维数ds、分形介质的表面分形维数Ds 的关系式.对吸附动力学数据的模拟表明,不同温度下6种染料在颗粒活性炭表面的吸附过程符合非线性动力学.吸附速率一般随着温度的升高而增加,反应活化能在0 2 0～1 75kJ·mol- 1 之间.上述反应为快速反应.进一步分析表明,该吸附过程具有类分形动力学特征,吸附反应的逐时速率系数k与反应时间t呈指数关系;相应的分形子谱维数ds<2 .随着染料的初始浓度的增加,ds 也随之增加,而h和k0 值通常会随之降低.吸附3种酸性染料时,h和k0 值在本实验的温度范围内均随着温度的升高而增加;其它3种直接性染料也大都呈现h随着温度的升高而增加的趋势.上述吸附反应中有效反应级数x也与ds、Ds 有关,呈现分数反应级数     

不同染料化合物在颗粒活性炭上的分形吸附规律

研究了颗粒活性炭对6种染料的吸附特征,结果表明,它们的吸附等温线均符合Ffendlich方程;由此计算出颗粒活性炭的表面分形维数均处于2到3之间．不同染料吸附时计算出的分形维数不同,吸附染料过程是在分形表面上发生的反应．吸附动力学过程分为快速吸附和慢吸附两个阶段,而且溶液中剩余染料的浓度变化动力学符合方程：Cout∝t^-α,表明该过程具有类分形动力学特征;并由指数α计算上述动力学反应的分形维数D．在实验的温度范围内,6种染料的吸附量和速度均随着温度的升高而增加;绿色染料吸附时的类分形动力学参数指数α和分形维数D也随之升高,而其它染料不呈现类似的规律．     

Indian dye yielding plants: Efforts and opportunities

The present review article deals with the information on the dye‐yielding plants of India. Dyes are intensively coloured compounds that are applied to a substrate such as fibre, paper, cosmetics, hair, etc. to give colours and can be extracted from the roots, fruits/berries, bark, leaves, flowers, and stem/wood, fungi, and lichens by various processes of extractions. In addition to their dye‐yielding characteristics, many of these plants possess medicinal values and can be used for multiple other purposes. Plant derived‐colours have an important role in human life because of their safe and eco‐friendly nature. But due to the availability of economically cheaper synthetic dyes, the indigenous knowledge of extraction, processing, and proper utilisation has been diminished. Nowadays, the demand for natural dyes has been increased worldwide due to awareness about their beneficial properties. It has been essential that proper documentation and measure of conservation should be undertaken to preserve these natural dye‐yielding plants. This review article is an aid to a collective inquiry into Indian dye plants.